Product ID:KERMAC 142 FLASH NAPHTHA
MSDS Date:10/18/1993
FSC:6850
NIIN:00-274-5421
MSDS Number: CFCSK

Emergency Phone: 713-638-4700/800-424-9300(CHEMTREC)

Info Phone: 713-638-4700

Cage: 6G213

Telephone: 713-638-4700/800-424-9300(CHEMTREC)

Cage: 6G213

SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC

CAS: 64742-88-7

Fraction By Weight: 100%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- EYES/SKIN:IRRITATION. INHALE:MAY CAUSE
RESPIRATORY IRRITATION, CNS EFFECTS, UNCONSCIOUSNESS. ORAL:HARMFUL
IF SWALLOWED. MAY CAUSE CNS DEPRESSI ON, NAUSEA, VOMITING.
ASPIRATION HAZARD. CHRONIC- MAY CAUSE DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DROWSINESS, DIZZINESS, NAUSEA,
VOMITING, HEADACHE, REDNESS, TEARING, BLURRED VISION, DEFATTING,
DERMATITIS, FATIGUE, UNCONSCIOUSNESS
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT, CNS MAY HAVE
INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:IMMEDIATELY
FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. SKIN:WASH WITH
SOAP & WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF
NECESSAR Y. ORAL:DO NOT INDUCE VOMITING EXCEPT ON ADVICE OF
COMPETENT MEDICAL PERSONNEL. IF CONSCIOUS, RINSE MOUTH WITH WATER.
KEEP PERSON WARM & QUIET. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.

Flash Point Method:TCC
Flash Point:142F,61C
Autoignition Temp:Autoignition Temp Text:450F
Lower Limits:0.7
Upper Limits:8
Extinguishing Media:USE FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T USE
DIRECT STREAM OF WATER; MAY SPREAD FIRE.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS. COOL
FIRE-EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTIBLE. WHEN HEATED ABOVE FLASH
POINT, WILL RELEASE FLAMMABLE VAPORS WHICH CAN BURN IN OPEN/BE
EXPLOSIVE IN CONFINED SPACES IF EXPOSED TO IGNITION SOURCE.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND, EARTH/PUMP (EXPLOSION PROOF).
GROUND ALL HANDLING EQUI PMENTS. PREVENT LIQUID FROM ENTERING
SEWERS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA
AWAY FROM SOURCES OF IGNITION. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID BREATHING VAPORS. DO NOT GET IN EYES, ON SKIN
OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. REMOVE CONTAMINATED CLOTHING PROMPTLY. LAUNDER BEFORE
REUSE.

Respiratory Protection:IF WORKING IN CONFINED AREAS, IF EXCESSIVE
MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES EXCEED RECOMMENDED
PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR NIOSH-APPROVED RESPIRATORY
PROTECTION FOR ORGANIC V APORS (REFER TO 29 CFR 1910.134).
Ventilation:ADEQUATE
Protective Gloves:NEOPRENE IF REPEATED CONTACT POSSIBLE
Eye Protection:SAFETY GLASSES/CHEMICAL SPLASH GOGGLES
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING, APRON, AND BOOTS IF SPILLS OR
SPLASHING CAN OCCUR.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health

HCC:V4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:350F - 415F
Vapor Pres:81 @ 100F
Vapor Density:5
Spec Gravity:0.78
Viscosity:1.3 CS @ 100F
Evaporation Rate & Reference:<1 (ETHYL ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID - PETROLEUM NAPHTHA ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
VARIOUS HYDROCARBONS MAY BE FORMED.

Waste Disposal Methods:RECLAIM BY DISTILLATION OR INCINERATE ABSORBED
MATERIALS IN A LICENSED HAZARDOUS WASTE FACILITY. DISPOSAL SHOULD
BE IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.